Auto transmission remove and replace

David Head v8q at bellsouth.net
Sun Jan 25 05:16:06 EST 2004


Wow - its been a long time since I thought about one of these... First 
off - did you get just the trans, or trans, torque converter and 
differential? I think I did a writeout on it once. It may be under 
dave.head at att.worldnet.net or some such.
These are really not that tough to do. Essentially, to remove the 
differential/trans as a unit you get it up on jackstands and remove 
everything that's in the way or attached to it, as the book sez. That 
book is your friend - it may not seem to give a lot of detail, but it 
does. Other than triple squares for the drive axles (and not always!), 
no special tools are needed. Its actually light enough - I would set it 
down on my chest when removing it, then slide out from under it.
My first audi was a 79 5KS - it was a great learning experience for Audi 
ownership. I went through 3 transmissions and a differential in that car 
- in a year. My understanding of Audi design was nil, and my expertise 
as a mechanic was basic - remove and replace. If you are at that level, 
you can still do this job. The first time I did the trans it took the 
entire day. The 4th time it took 3 hours start to finish.
There really aren't any adjustments as such. Its a very basic 3 speed 
trans. You have a load sensing arm that comes off the throttle assembly, 
I remember that much...
If you are replacing the trans only (cute little square box), there's 
more...

Mary and Case wrote:

>All,
>
>Many thanks for your help in the past.  I am asking for help once again.  I have recieved a replacement 087 transmission for our '89 Audi 100 from Chris at Force 5.  I have also purchased a Bentley Manual for the car.  The document assumes a knowledge and competence that I fall just shy of, so..
>
>First, is there an archive that will provide greater insight into the processof removing and replacing the auto trans?
>
>Have any of you done it and written about it?
>
>Where is the speedo connection?
>
>Can I just disconnect and reconncet everything or will I need to make adjustments?
>
>Should I drink German beer while working on the car to improve the Karma?
>
>Thanks to all!
>
>Case
>_______________________________________________
>quattro mailing list
>quattro at audifans.com
>http://www.audifans.com/mailman/listinfo/quattro
>
>  
>




More information about the quattro mailing list