[urq] Better fuel pump needed

[Ben Swann]

OK - I just wish folks would just answer my questions.  The part about Autohaus AZ is
helpful, as that provides a potential source for the solution.

I don't have a stock application and need a higher flow, higher output pump.  I the
recent past I have seen many Bosch pumps that came as "remanufactured" even though not
specified as such when purchasing.  Some may have been new.  They were garbage.

I want a high output high flow high reliability pump.  Sources are helpful.

Thanks,

Ben

-----Original Message-----
From: Brandon Rogers [mailto:brogers at terrix.com] 
Sent: Friday, October 05, 2007 3:31 PM
To: 'Ben Swann'; urq at audifans.com
Cc: quattro at audifans.com
Subject: RE: [urq] Better fuel pump needed

Rebuilt?  I don't recall the one I got being a rebuilt.  Why Spend $300
when you can get the right part for ~$100 less.  Call Scott Mockry or
Autohaus AZ.

Brandon

-----Original Message-----
From: Ben Swann [mailto:benswann at comcast.net] 
Sent: Friday, October 05, 2007 1:17 PM
To: 'Brandon Rogers'; urq at audifans.com
Cc: quattro at audifans.com
Subject: RE: [urq] Better fuel pump needed


As I mentioned, the rebuild quality of pumps were not good a few years
back.  I just don't want to make the same mistake again.

Indeed I should be able to get a good new Bosch pump for under $300.  I
will use the latest highest output pump I can find.  The pump for the NG
cars was a bit higher output than the UrQ one, but I agree, the older
pump should be fine - just why not get the beefier pump?

Ben

-----Original Message-----
From: Brandon Rogers [mailto:brogers at terrix.com] 
Sent: Friday, October 05, 2007 3:19 PM
To: 'Ben Swann'; urq at audifans.com
Cc: quattro at audifans.com
Subject: RE: [urq] Better fuel pump needed

I have a plain old stock urq fuel pump with my urq with somewhat RS2'd
3B pushing 22+ psi - fuel is not an issue - so it shouldn't be for you
either.  Make sure you are getting good voltage to the pump.  Stock urq
pumps were about $190 last I heard....

Brandon

-----Original Message-----
From: urq-bounces at audifans.com [mailto:urq-bounces at audifans.com] On
Behalf Of Ben Swann
Sent: Friday, October 05, 2007 9:36 AM
To: urq at audifans.com
Cc: quattro at audifans.com; 'Ben Swann'
Subject: [urq] Better fuel pump needed


Turns out one of the problems I've had with my Megasuirt EFI
installation and tuning has been a crappy fuel pump.  It limits flow and
the engine was running crappy at 5k and now is cutting out at lower RPM
and even idle too - buzzing is very load. Now this is the third or
fourth pump I've installed in this car.  The first pump was totally
seized from setting when I got the car about 5 years ago.  I purged the
lines and flushed the tank and installed a pre-filter.  I installed an
87.5 Coupe GT/Model 90 pump - higher flow and pressure. The first one
was defective out of the box.  The second one is now acting up.  Tank
was just flushed and I routinely replace the pre-filters even though
they look clean, so I don't think any garbage is getting into the pump.


So I am looking for recommendations for the best pump to use since I no
longer have CIS. I would be nice to have the output fitting mate with
the stock fitting, but mainly I want a reliable high output and pressure
pump.  The inlet is already using a larger hose.  I'm tired of doing
jobs 2 and 3 times, so this time I won't try to skimp on cost, although
the ones I've been putting in a Bosch Replacements.

Recommendations?

Ben
_______________________________________________
Audifans urq mailing list
Send posts to: mailto:urq at audifans.com
Manage your list connection:
http://www.audifans.com/mailman/listinfo/urq
Have an urq question?  Check the Audifans Knowledgebase!
http://www.audifans.com/twiki/bin/view/Audi/UrQuattro
Have an urq answer? ... Please help others by adding to the KB ... all
contributions welcome!

You can help keep the audifans site running by shopping at
http://audifans.com/shop/