[s-cars] Viscous fan clutch failure?

[djdawson2 at aol.com]

Still yet, the best solution is the fan clutch that is activated much like the A/C clutch.  No engagement at all when not required, and then full engagement when needed.
 
Haven't seen that on cars yet.
 
 
-----Original Message-----
From: josh at spiny.com
To: StrangConst at rogers.com; S-CAR-List at audifans.com
Sent: Fri, 11 May 2007 4:33 PM
Subject: Re: [s-cars] Viscous fan clutch failure?


Mark, that might be true on old cars without modern fan clutches, but  
the clutch is there to keep the fan from robbing too much power, and  
also to keep the noise down.  The idea is that the hotter the air  
gets around the fan, the more air it moves.  Plus, a viscous clutched  
fan is able to move much more air than an electric fan, and more  
reliably too. They're not without their problems, but they do have  
some important advantages over electric fans.

On May 11, 2007, at 8:36 AM, Mark Strangways wrote:

> Yank that sucka outta there and put in an electric.
> Good for about 30-50 HP... Dyno proven
>
> Mark
> ----- Original Message -----
> From: "Peter Golledge" <petergolledge at gmail.com>
> To: <s-car-list at audifans.com>
> Sent: Friday, May 11, 2007 9:05 AM
> Subject: [s-cars] Viscous fan clutch failure?
>
>
>> Folk,
>>
>> My wife reported some unusual noise from her 95 S6 and no A/C.  I  
>> check
>> out
>> the car last night... everything seems fine.  Get it up to  
>> operating temp
>> with a drive, still no problems.  Looking at the primary fan I see it
>> turning maybe 60 rpm with the engine idling.  Stops with the touch  
>> of bit
>> of
>> plastic scrap.  No huge play in the clutch but I suspect its  
>> dead.    Any
>> BTDT on the list?
>>
>> With the fan blades off I can easily get a big 32" spanner on the  
>> clutch.
>> Anyone removed it by holding the pulley with rubber filter strap or
>> similar?
>>
>> Regards
>> -- 
>> Peter Golledge
>>
>> 95 S6, 89 200TQA, 87 LT-1Q, 1979 930
>> _______________________________________________
>> S-CAR-List mailing list
>> S-CAR-List at audifans.com
>> http://www.audifans.com/mailman/listinfo/s-car-list
>>
>
> _______________________________________________
> S-CAR-List mailing list
> S-CAR-List at audifans.com
> http://www.audifans.com/mailman/listinfo/s-car-list

_______________________________________________
S-CAR-List mailing list
S-CAR-List at audifans.com
http://www.audifans.com/mailman/listinfo/s-car-list
________________________________________________________________________
AOL now offers free email to everyone.  Find out more about what's free from AOL at AOL.com.