[V6-12v] Radiator Fans not working

[T. Jackson]

Thanks for the list.  I did find one other fuse that I had missed which is
in spot 20 I believe and it is a 30 Amp fuse for Fan speed 1.  This fuse
also seems to be fine.  I also looked for fuse S42 but could not find it.
Is this fuse located under the dash or under the hood?

With respect to the relays, how can I test that these are not the problem?
Know Audi they are likely to be expensive to replace so I don't want to
attempt to buy them unless I absolutely have to.  


Are there any 93-95 90 owners in the Greater Toronto Area that are willing
to help with the swap?



-----Original Message-----
From: v6-12v-bounces at audifans.com [mailto:v6-12v-bounces at audifans.com] On
Behalf Of Tom Christiansen
Sent: Monday, September 20, 2004 10:45 PM
To: T. Jackson; 'V6 12V Audi Mailing List'
Subject: Re: [V6-12v] Radiator Fans not working

The fan speed is controlled by a thermal switch located on the starboard 
side, bottom of the radiator just above the drain  plug. I forget how many 
speeds the fan has but I think it's three. The different speeds are set 
with a resistor pack located on the port side sub-frame. It's pretty easy 
to find if you trace the wires from the fans. It looks like an L-bracket 
with a couple of wire taps on it.

So there are a couple of possibilities for failure:
1) The fans themselves.
2) The two relays driving the fans: The one at position 18 (high speed) and 
the other at position 11 (low speed).
3) The resistor pack.
4) The thermal switch.
5) Fuses S15 (25 A) and/or S42 (60 A).

The fan is supposed to run at full speed when the A/C high pressure switch 
engages. I would assume it does so when the A/C is running. The fan on my 
1994 90S normally turns on at low speed when the temp gauge reaches about 
straight up (whichever temperature that is).

If you click "wiring diagrams" in the Bentley manual, then select your 
model year, and select "manual climate control" you should be guided to 
page 102 in the manual. It has the relevant schematic.

Tom

At 05:06 PM 9/20/2004, T. Jackson wrote:
>I noticed this morning while sitting in traffic that my car was running a
>little warmer than normal.  After a while the traffic cleared up and I
>started moving so the car temperature stayed nominal until I got to work
and
>forgot about the abnormal temperature reading.  On the way home after
>sitting in traffic I noticed my temperature gauge slowly approaching the
>120C mark while my oil temp was around 130C!  I managed to get the car
>moving again and cool enough to pull over and check the fuse box.  The fuse
>seemed to be in good shape and the label on the box indicated that it is
>shared with other items like turn signals and wipers which all appear to be
>working.  Before continuing the drive on the open road I did a quick check
>to see if there were any disconnected wires or harnesses and I couldn't see
>any.  It was much too hot to go prodding in the engine bay so I saved
myself
>the potential 3rd degree burns and I will take a look at it in the morning
>when it's much cooler.
>
>
>Does anyone have any ideas as to what I should be looking for?  Is it
>feasible to test the fans by applying 12V from the battery to the connector
>(where ever it is)?
>
>
>BTW, the car is a 1995 Audi 90 Quattro.
>
>Thanks!
>
>
>_______________________________________________
>V6-12v mailing list
>V6-12v at audifans.com
>http://www.audifans.com/mailman/listinfo/v6-12v

_______________________________________________
V6-12v mailing list
V6-12v at audifans.com
http://www.audifans.com/mailman/listinfo/v6-12v