[Vwdiesel] Changing the 5 speed trans fluid
TexasTDI
texasvwdriver at hotmail.com
Sat Nov 1 09:54:52 EST 2003
It's definitely not a Phillips. The "bolt" has a star-shaped hole in it.
Not a screwdriver, not an Allen wrench. The bolt is also six sided, so I
guess a socket could get it off as well. But the bolt is quite thin, so I'm
not sure how much of a bite I can get on it with a socket.
I've changed gear lube in manual transmissions before. That part I'm not
worried about. My main concern was removing and reinstalling the
speedometer cable. I can't afford to mess that up. };-)
Chris Thornton
1991 VW Jetta 2 Door 1.6 Diesel - 240k miles
2000 VW Golf 1.9 TDI (turbo diesel) - 89k miles
Amsoil Synthetic Lubricants Dealer #1098500
http://www.amsoil.com
----- Original Message -----
From: <LBaird119 at aol.com>
To: <vwdiesel at vwfans.com>
Sent: Thursday, October 30, 2003 9:49 AM
Subject: Re: [Vwdiesel] Changing the 5 speed trans fluid
> --
> [ Picked text/plain from multipart/alternative ]
> Anybody out there ever change the gear lube in their 5 speed? Looking in
> the Bentley Manual it says to pour in the new fluid through the hole that
> the speedometer cable goes into. What size Torx does it take? Are there
> any special things I need to know when removing and reinstalling the
> speedometer cable? TIA
>
>
> Drive until warm, jack up as needed to get the drain hole lowest and
> pull the plug. You'll put back about 2 quarts but don't trust the level
> check hole necessarily, many were too low, about a half quart! My
> speedo cable is held in with a big, #3 or #4 phillips. Only Torx I've
> seen on a VW engine, holds the oil squirters in.
> Loren
More information about the Vwdiesel
mailing list