[Vwdiesel] E.J.'s Bounce
Sandy Cameron
scameron at compmore.net
Wed Sep 29 20:28:31 EDT 2004
At 04:09 PM 29/09/04 -0700, you wrote:
Drained the transmission. The fluid which was Redline GL 4 was quite dark.
I measured the drained volume and it was approximately 1.3 quarts. I know
that the 5th gear sets high in the transmission and needs exactly 1 quart to
remain lubricated from comments on the list.
By the way, as Roger points out, You can NOT fill an A2 transmission from
underneath, due to the tilt of the transmission and engine.
You must remove the speedometer cable (and gear ) from the top of the
transmission, after you have drained it and replaced the plug, and fill it
through the speedo hole with 2 QUARTS /LITERS of oil. This is detailed in
both the haines and bentley manuals.
Later trannies have had the fill hole plug set higher up on the case to
correct this.
Any time you are suspicious of the amount of oil remaining, drain it and
refill with 2 quarts. Safest system.
Sandy
More information about the Vwdiesel
mailing list