[Vwdiesel] 5-speed trans wanted
Hayden Chasteen
dieseltdi at verizon.net
Mon Nov 27 13:18:07 EST 2006
The TDI will work with an FN or FF trans but....rpms may be a little high
and more importantly, you will probably tear it apart with the torque of the
TDI. In my truck conversion, I used the stock 02A trans from my Passat
Donor car. You will have to source or manufacture mounts for the front
(drivers side) and rear of the trans as the stock ones won't work. Look on
VWvortex, these things come up for sale from time to time on there. Then
you will have to decide if you are going to go with a hydraulic clutch
system (more fabrication) or switchout for a cable system like was used on
European Eurovans. This uses a mechanism to take the place of the hydraulic
actuator, a clutch cable and a transmission mounted cable guide/brace (no
longer available but easy to fabricate). Then you have to mount the cable
shifter and decide if you want it on top of the tunnel or below (I opted for
on top). So there are many decisions that will have to be made. If you
have a good sturdy FF or FN available, or can get it rebuilt, then you can
survive with it for a time. Look on my website for more information on my
Caddy TDI swap. Hayden
http://mysite.verizon.net/resosxp8/mydieselpages/id14.html
"Those who would sacrifice Liberty for Security, deserve neither Liberty nor
Security." B. Franklin
"This country would be a lot easier to run if it were a dictatorship....as
long as I was the Dictator!" Pres. George W. Bush
----- Original Message -----
From: <lbaird119 at aol.com>
To: <donohue at rnetworx.com>; <vwdiesel at vwfans.com>
Sent: Monday, November 27, 2006 11:40 AM
Subject: Re: [Vwdiesel] 5-speed trans wanted
> Maybe Hayden can pipe in here. :-) You'll want a later, TDI's 5 speed
> to be happy with the
> whole thing. The TDI likes much lower cruising rpm than the Older IDI
> engines do. With that
> comes the cable shifter swap-in also.
> Loren
>
>
> -----Original Message-----
> From: donohue at rnetworx.com
> To: vwdiesel at vwfans.com
> Sent: Sun, 26 Nov 2006 3:07 PM
> Subject: [Vwdiesel] 5-speed trans wanted
>
>
> Just signed on this list today. Tried to post this want ad earlier, but
> apparently sent it before I was officially a member! Here goes again. My
> son
> has an '82 Rabbit pickup in the midst of a TDI engine conversion. The
> truck has
> the 4-speed trans and he would like to install a 5-speed...any btdt,
> advice, or
> ideas where he might find one? He lives in the San Jose, CA area.
> Thanks, Tom
> Donohue
> _______________________________________________
> Vwdiesel mailing list
> Vwdiesel at vwfans.com
> http://www.audifans.com/mailman/listinfo/vwdiesel
> ________________________________________________________________________
> Check out the new AOL. Most comprehensive set of free safety and security
> tools, free access to millions of high-quality videos from across the web,
> free AOL Mail and more.
> _______________________________________________
> Vwdiesel mailing list
> Vwdiesel at vwfans.com
> http://www.audifans.com/mailman/listinfo/vwdiesel
More information about the Vwdiesel
mailing list