[Vwdiesel] 2003 Golf ALT symptoms - any other possibilities?
Travis .
tgott at hotmail.com
Thu Aug 14 11:47:03 PDT 2014
The alt pulley takes 1/2 hour if you have never done one before. Taking the whole alt out takes likely 2 hours to do and the much greater parts cost. As for them failing at the same time-I replaced my alt pulley at around 70K miles. I was at 150K miles when my 04 started on fire shorting out at -35 outside and there were no pulley issues yet nor alternator issues (fire near starter-not alt). I know I would only do the pulley again.
Travis
From: tadc at europa.com
Date: Thu, 14 Aug 2014 11:01:49 -0700
Subject: Re: [Vwdiesel] 2003 Golf ALT symptoms - any other possibilities?
To: malkire at gmail.com
CC: tgott at hotmail.com; vwdiesel at vwfans.com
Sounds familiar - my alt pulley started making funny noises and broke a few minutes later.
The guy at my shop recommended just replacing the whole alt because it often doesn't last much longer than the pulley and the labor isn't cheap to do twice.
On Wed, Aug 13, 2014 at 2:55 PM, Matt Alkire <malkire at gmail.com> wrote:
This happened to me. My pulley started chirping, so I ordered a new one. The day after ordering, the old one exploded. Took the alternator belt with it.
It was around $30 for the pulley and $35 for the tool.
The sad part is, 6 months later the alternator died.
-Matt
> On Aug 13, 2014, at 4:56 PM, "Travis ." <tgott at hotmail.com> wrote:
>
> The alt pulley is a clutched pulley. Sometimes they fail and lock solid. Sometimes they start to slip and don't turn the alt over enough to charge. Rarely but it does happen-the pulley explodes. Pull the belt off, put a screwdriver into the inside fan blades and then turn the pulley. It should turn one direction only. If turns both or neither it is bad. $65 is cheaper then $400. You need a special tool/s to get the pulley off (another $35 or can be rented from someone).
> Travis
>
> _______________________________________________
> Vwdiesel mailing list
> Vwdiesel at vwfans.com
> http://www.audifans.com/mailman/listinfo/vwdiesel
_______________________________________________
Vwdiesel mailing list
Vwdiesel at vwfans.com
http://www.audifans.com/mailman/listinfo/vwdiesel
More information about the Vwdiesel
mailing list