audilary fan is acting "moody"

Phil Rose pjrose at frontiernet.net
Fri Dec 3 12:04:36 PST 2010


Actually it's called a "fusible link" that connects the fan motor to 
ground (not power). They routinely go bad from flexing or other 
stresses (thermally induced?) which cause a hairline crack that can 
be *very* hard to see. A replacement link from the dealer (!) costs 
only a buck or two, so don't hesitate to see your favorite dealer and 
order a couple of 'em.

Phil


At 12:52 PM -0800 12/3/10, robert weinberg wrote:
>Thanks Pete!
>
>man, i don't know what i'd do without this board! ;-)
>
>see ya,
>Robby
>
>
>
>
>________________________________
>From: "PeterBergin at aol.com" <PeterBergin at aol.com>
>To: centaurus3200 at yahoo.com; 200q20v at audifans.com
>Sent: Fri, December 3, 2010 12:47:35 PM
>Subject: Re: audilary fan is acting "moody"
>
>Yea, there is a metal fuse (might be 80 AMP) under the hood in a 
>black box  near
>the driver side inner fender.  Easy to spot.  They corrode and go  bad (BTDT
>twice).  I keep a spar in the glove box.  Look at it and  clean it.
>
>May as well check all plug connections going to the fan, including the  speed
>controller mounted in front of the AC condenser low, under the plastic  piece
>the removes between the radiator and the front end.
>
>Pete, 91 Avant
>
>In a message dated 12/3/2010 2:35:16 P.M. Central Standard Time, 
>centaurus3200 at yahoo.com writes:
>hi    all,
>>
>>driving home a few days ago - the temp gauge went past the usual 
>>spot where
>>the
>>
>>aux fan turns on. the car never got close to hot, but it    was unnerving.
>>
>>i noticed that there was a big draw on the voltage gauge    when 
>>the fan should
>
>>turn on. like a split second, then the gauge went    back, but the 
>>fan did not
>>turn
>>
>>on. but it seems it was trying to turn    on.
>>
>>when i pulled into the driveway, the fan did switch on.
>>
>>is    there some thermal relay that's suspect or is the aux fan on 
>>it's way   
>>out?
>>
>>Robby
>>
>>
>>
>>     
>>_______________________________________________
>>200q20v mailing    list     http://www.audifans.com/mailman/listinfo/200q20v
>>
>
>
>      
>_______________________________________________
>200q20v mailing list	 http://www.audifans.com/mailman/listinfo/200q20v


-- 

Phil Rose
Rochester, NY
mailto:pjrose at frontiernet.net


More information about the 200q20v mailing list