Slave cylinder stuck in tranie?

Denis sparkplugvw at hotmail.com
Thu Dec 2 12:28:04 EST 2004


  It s a good procedure , i did , hard way,,,, hands ouchhhh couple time.
  As he said penetreting oil needed, wait , knock again, be careful , dont damage the tranny case.

  To remoove the pin i used a graded wood screw and an hammer...the slave is hard to reach so....be patient , as you saw :-)

  Once the slave was twisting i put bach the hose and use it to grap tha slave qith hands to twist and get out.
  Ðenis

  sorry for my english, you might prefere in french :-)
    ----- Original Message ----- 
    From: David Kavanagh 
    To: jpinkowish at aol.com 
    Cc: quattro at audifans.com 
    Sent: Thursday, December 02, 2004 12:16 PM
    Subject: Re: Slave cylinder stuck in tranie?


    Geeze, I happen to think that getting your hand whacked by a hammer or
    crow bar builds character (and scar tissue)!!

    :)


    On Thu, 2 Dec 2004 12:08:21 EST, jpinkowish at aol.com <jpinkowish at aol.com> wrote:
    > In a message dated 12/2/04 9:52:43 AM EST, rob3 at hod3.fsnet.co.uk writes:
    > 
    > 
    > 
    > > Eventually I selected a two and a half
    > >  foot chisel tip crowbar and located that on the slave cyl. on the boss
    > where
    > >  the hydraulic hose connection is. (hose already removed). The other end was
    > >  then conveniently above the bonnet (hood?) slam panel. Then I selected a
    > 7lb
    > >  hammer and whacked the end of it. This did the trick in getting that first
    > >  movement and from there I was able to twist, spray lube and revert to small
    > >  hammer to finally get it out.
    > 
    > This is precisely what I did to free the slave in my 4kq.  However, I only
    > used a 2 or 3lb hammer.  Two or three whacks, and the cylinder was free.
    > 
    > Keeping the chisel tip of the crowbar on the boss for the hydraulic hose is
    > important.  Also, wear a glove on the hand holding the crowbar.  It dampens the
    > vibration from the whacks and should provide a little protection from the
    > hammer if you miss the crowbar and graze your hand.
    > 
    > Jan Pinkowish
    > '85 4ksq
    > Bristol, CT
    > 
    > 
    > _______________________________________________
    > quattro mailing list
    > quattro at audifans.com
    > http://www.audifans.com/mailman/listinfo/quattro
    > 


    -- 
    '00 A6 biturbo 6-speed
    '01 allroad 6-speed
    _______________________________________________
    quattro mailing list
    quattro at audifans.com
    http://www.audifans.com/mailman/listinfo/quattro



More information about the quattro mailing list