[s-cars] 95.5 S6 No/Low Heat

[Todd Prokop]

Sounds to me like maybe the temp flap servo - I just did mine in my 95.5.
You can get the CC unit into diagnostic mode, and it should tell you where
the trouble is:

http://forums.quattroworld.com/a6100/msgs/3334.phtml

I expect you to return a trouble code in the 8s, most likely 08.5.  If
that's the case, here's the R&R step by step:

http://12v.org/urs/FredMsTempFlapMotorR&R.pdf

Good news is the servos are still available.


On Fri, Jan 8, 2016 at 10:49 AM, Bares, Vittorio <Vittorio.Bares at nuance.com>
wrote:

> I just fixed this problem on my S6 (albeit I had the opposite problem,
> full hot all the time).
>
> Best way to diagnose is to use a full version of VAG and run through each
> of the climate control tests.
>
> The symptoms sound like Flaps and or  motors - there are 4 total, 2 that
> are fairly easy to get to from under the hood. I forget which controls
> what, believe the one on the drivers side is temp (have to remove cowling
> and wiper assembly for this one).
>
> There are instructions on the inter webs on how to mark the one on the
> pass side, and also how to open the motors and clean them. I should have
> kept that link :\
>
> -----Original Message-----
> From: S-CAR-List [mailto:s-car-list-bounces at audifans.com] On Behalf Of
> Paul Luevano
> Sent: Friday, January 08, 2016 10:07 AM
> To: s-car-list
> Subject: [s-cars] 95.5 S6 No/Low Heat
>
> List-
>
>         It's getting cold in the northeast, so of course the heat in my S6
> is getting flaky.
>
>         Noticed the other morning that the car was never heating up.  It
> usually gets to temperature, even on the coldest mornings, in 5-10
> minutes.  Now, at the end of my (admittedly short commute), the car is
> barely starting to warm up.
>
>         Did a little digging this morning, and while the dash gauge is
> showing normal temp (thermostat just replaced in preparation for the
> winter), no matter where I set the climate control settings (dash, floor,
> center vents, etc.), it is blowing cool to luke warm air at best.
>
>         Thoughts?
>
>         Thanks!
>
> Paul Luevano
> 95.5 UrS6
> Wakefield MA
> _______________________________________________
> S-CAR-List mailing list
> http://audifans.com/mailman/listinfo/s-car-list
> http://www.audifans.com/kb/List_information
> _______________________________________________
> S-CAR-List mailing list
> http://audifans.com/mailman/listinfo/s-car-list
> http://www.audifans.com/kb/List_information
>