[urq] tranny seal leak - prop shaft
Martin Pajak
martin at quattro.ca
Thu Dec 13 17:37:04 PST 2007
Just to add to the excellent description.
I also changed the bearing at the same time.. sort of while I'm in there.
Cheers
Martin
> -----Original Message-----
> From: urq-bounces at audifans.com [mailto:urq-bounces at audifans.com] On Behalf
> Of Fluhr
> Sent: December 13, 2007 4:33 PM
> To: urq at audifans.com
> Subject: Re: [urq] tranny seal leak - prop shaft
>
>
>
> Brandon says:
> >So it looks like I have a leak in the prop shaft output seal on my
> >tranny (stock '84 016). Sweet. I'm told you are supposed to remove
> >tranny and separate from the diff ( I think) in order to get to that
> >seal. Anybody know different - or know a shortcut? According to Ben
> >this is just a little bit of work...ha!
>
> I just did this on my '82 urq, and it was not nearly that hard.
> I did not have to remove the whole diff, the back of the rear diff
> comes off. You have to disconnect the prop shaft at the
> tranny. Then just take off a few bolts and pull out the rear
> diff cover, which includes the output flange & shaft & bearing &
> diff lock gear. I needed a press and some heat to get the gear
> off the shaft, which was the hardest part of the entire procedure.
> That let me pull the shaft out so I could get to and replace
> the seal. Installation is the reverse of removal.
>
> The Bentley has good pictures on this.
>
> In the midst of replacing my seal, I found that my leak was not
> caused by the propshaft seal, but by a plug in the diff housing
> on top of the tranny that had come out. It is hard to see and
> get to, and the Bentley shows that later versions were threaded
> instead of the early plastic push-in plug. Check yours if you
> are losing tons of tranny fluid rather than just a small leak.
>
> Later,
> Eric
> '82 urq
> _______________________________________________
> Audifans urq mailing list
> Send posts to: mailto:urq at audifans.com
> Manage your list connection: http://www.audifans.com/mailman/listinfo/urq
> UPG2008 planning at: http://autos.groups.yahoo.com/group/urquattro/
>
> You can help keep the audifans site running by shopping at
> http://audifans.com/shop/
More information about the urq
mailing list