[V8] 2231 code hell, i'm at my wits end!

Ron Wainwright ron_01056 at yahoo.com
Thu Oct 20 20:56:07 PDT 2011


Paul, thanx for the response. When I had the miss fire I replaced caps/rotors/plugs/plug wires/o2 sensor/pass side dizzy (hall sender) When I pulled the old caps I checked them for any thing and found nothing wrong with them. No cracks or excessive carbon build up. When I replaced the wires I checked the old ones. #4 had a bad plug top from someone having a hard time pulling it I would imagine....it still ohmed out though. But I replaced them anyway.
 I can get in the car and it will run great for like 10 min. This is in the morn on my way to work. Most the trip is highway driving. I can change gears at 5/6G with no hesitation/miss fire/hick up! Ie she runs like a raped ape.When the car acts up it's weird. I can b driving no problem but when I get off then throttle it's like I stabbed the brake instead of the clutch...know what I mean? And getting back on the throttle the pedal feels sticky...but it's not....getting back on the throttle the car feels like I got tapped on then rear bumper...know what. I mean?  My gas mileage has been decent. It was round 15 now it's like 19 but should b higher. It has been suggested to me to trace the ISV circuit. Does anyone know were the ISV circuit ground is? The book said it's in the wiring harness...but I replaced the harnness. Unless I'm reading the book wrong?
 Ron 
-- On Thu, 10/20/11, Paul DAnneo <padanneo at sbcglobal.net> wrote:
From: Paul DAnneo <padanneo at sbcglobal.net>
Subject: Re: [V8] 2231 code hell, i'm at my wits end!
To: "Ron Wainwright" <ron_01056 at yahoo.com>
Cc: "Audi" <v8 at audifans.com>
Date: Thursday, October 20, 2011, 11:35 PM

Hey Ron,My V8(91 3.6) I have chased around a bunch of codes and did continually get the 2231 code reaccuring. My problem was ignition related. After a full ignition tune, wires, plugs, caps, rotors, O2 sens. Codes cleared.Hope this helps,Paul
From: Ron Wainwright
 <ron_01056 at yahoo.com>
To: v8 at audifans.com
Sent: Thursday, October 20, 2011 2:50 PM
Subject: [V8] 2231 code hell, i'm at my wits end!


I guess the long and short of it is I just can't get rid of the ISV code.I've been getting the code for about 2 months now and have went through everything....
 The weird thing about it is the ISV is brand spanking new. I found one on ebay NOS (new old stock). When I got it, it was as advertised clean as a whistle! 
 in the time I have been getting the ISV code I have all so gotten codes for,02 sensor and iat. So I replaced,  02 sensor. I was getting an oscillating idle. It would go from 1,000 to 1,600'ish and kept repeating till I would hit the throttle. Allen unplugged the Green wire and it went away. So I replaced it and works as it should now IAT. The one in the car looked fine. Wires were fine as well. I had cut the sheeth back and checked the wires and they were fine. it was solidly sotered still to the sensor. the wire and diod thing was a little dirty, I cleaned it looked fine ect. I replaced it
 anyway with a new 4.2/Urs4/6 plug in type and the correct connector. 
 I all so replaced all the breather hoses, valve cover to cover, rear driver side, front intake, the small one that goes around the rear intake opening. I all so replaced the one's that go from the valve on the pass side fire wall, (it's Yellow and Black). There's a hose that goes to the back of the pass side intake, a small one coming from under the rain deverter and a length of the hard Black plastic type hose running along the firewall.
 I tried another ECU...one from a 5sp. I pulled the original engine wiring harness. Which meant I had to pull the Intake. So I replaced the intake gaskets, and Green Knock sensor as well. I replaced the MAF, tried two different TPS's and know I have adjusted them correct! Allen even did it a few times just to make sure I was doing it rite...... I have tried two different throttle bodies as well. All
 related fuses are fine ect.....
 I had a friend check codes with his scanner and couldn't clear the ISV code. It would go away but pop rite back up while the computer was still hooked up to the car and with the car off!
 I need help! I have no idea were to look next????
 Ron

_______________________________________________
Audifans V8 mailing list
Send posts to: mailto:V8 at audifans.com
Manage your list connection: http://www.audifans.com/mailman/listinfo/v8

You can help keep the audifans site running by shopping at http://audifans.com/shop/





More information about the V8 mailing list